405-bhp, more to go...

[2om]

Начало во всем встать 1.
Текущая спецификация.

Here is the current spec list......

ENGINE

200 COSWORTH BLOCK
STANDARD STEEL CRANK, STANDARD STEEL CON RODS
GENUINE COSWORTH PISTONS
LOW COMPRESSION (7.6:1)
HIGH PRESSURE OIL PUMP
BIG WINGED SUMP (1 litre extra)
WRC METAL 4 LAYER HEAD GASKET
LONG STUDDED
4X4 POLISHED & PORTED HEAD
HARVEY GIBBS CAMS
KENT ADJUSTABLE VERNIERS
PORTED INLET MANIFOLD AND PLENUM
INLET MANIFOLD ‘O’ RINGED
4X4 EXHAUST MANIFOLD
GT28 ROLLER BEARING TURBO WITH MODIFIED T34 FRONT HOUSING
GARRETT –31 ACTUATOR
GROUP A CAM BELT
GROUP A COIL
GENUINE RS500 INTERCOOLER WITH MODIFIED T34 FITTINGS
PACE RS500 FAST ROAD RADIATOR (50mm core)
PRO-ALLOY SLIMLINE UPRATED COOLING FANS
PACE TURBO COOLER
BAILEY MOTORSPORT TURBO OIL FEED & PRE FILTER
SPEC-R GROUP A BREATHER/SEPARATOR SYSTEM
SPEC-R CAMBELT COVER
SPEC-R SWIRL POT
SPEC-R WATER COOLED POWER STEERING TANK
SPEC-R HEADER TANK (with sight glass)
SPEC-R WASHER BOTTLE
STANT 21-25psi RADIATOR CAP WITH LEVER RELEASE
SAMCO BOOST & WATER HOSES
BRAIDED FUEL HOSE -6 WITH EARLS FITTINGS AND CLAMPS
(from filter to fuel rail, and regultor to tank)
MIKALOR STAINLESS STEEL HOSE CLAMPS THROUGHOUT
2 AIR SCOOPES ABOVE INTERCOOLER WITH DUCTING TO AIR FILTER
MONGOOSE 3in STAINLESS STEEL EXHAUST (with Powerflex hangers)
K&N GROUP A CONE FILTER
WEBBER MARELLI LEVEL 8 ECU WITH PECTEL BABY BOARD
PECTEL 12 POSITION BOOST CONTROL (in car)
4 X 403 GREY INJECTORS (503cc)
WRC AIR INJECTORS WITH –4 BRAIDED HOSE AND EARLS FITTINGS
WATER INJECTION
044 FUEL PUMP
3 BAR MAP SENSOR
MOTORCRAFT AGP 701 SPARK PLUGS
FORD MOTORSPORT IGNITION LEADS
MILLERS 10w60 FULLY SYNTHETIC OIL
9 OIL COOLER FOR POWER STEERING


TRANSMISSION

STANDARD BORG WARNER T5 WITH QUICKSHIFT
CASTROL AUTOMATIC TRANSMISSION FLUID (as standard)
LIGHTENED & BALANCED FLY WHEEL
ALCON 6 PADDLE, STANDARD FORD COVER
RECONDITIONED PROPSHAFT WITH UPRATED UJ’S
QUAIFE ATB 7 ½ INCH DIFF, 3.64:1 FINAL DRIVE (standard)
CASTROL EP80W-90 OIL


POWER

405 bhp @ 6030 rpm
397 lbft TORQUE @ 4020 rpm
REV LIMITER : 7100 rpm
PEAKS @ 32 psi, HOLDS 28psi
BUILT & TUNED BY HARVEY GIBBS
SCS, PETERBOROUGH. 01733 576614
MAPPED BY AHMED BAYJOO ON DYNO & IN CAR


BRAKES

FRONT: AP RACING CP5555 6 POT CALIPERS
330mm x 28mm DISCS & BELLS
FERRADO DS2500 PADS

REAR: 4x4 CALIPERS
300mm x 22mm DISCS & BELLS
FERRADO PADS
GOODRIDGE BRAIDED HOSES ALL ROUND
CASTROL SRF DOT 4 BRAKE FLUID


SUSPENSION

FRONT: GAZ COILOVERS
10 INCH SPRINGS, 325 LB
POLY BUSHED ANTI ROLL BAR AND TRACK CONTROL ARMS (inner
& outer)
SPEC-R TWIN BAR STRUT BRACE (chromed)


REAR: GAZ COILOVERS
12 INCH SPRINGS, 225LB
GROUP N REAR BEAM BUSHES (donuts)
STANDARD FORD TRAILING ARM BUSHES
POLY BUSHED REAR ANTI ROLL BAR
REAR SHIM KIT
SPEC-R REAR STRUT BRACE

INTERIOR

STANDARD RECARO INTERIOR
RS MOTORSPORT 3 SPOKE STEERING WHEEL
WILLINS 4 POINT HARNESSES
ELLIOT 8000 RPM REV COUNTER
DEFI OIL PRESSURE & TEMPERATURE AND EXHAUST GAS TEMPERATURE
DEFI CONTROLLER (with record and playback)
APEXI 2.5 BAR BOOST GUAGE (with record and playback)
S.E.C.S MONITER
PECTAL 12 POSITION BOOST CONTROL
SPEC-R WATER INJECTION TANK IN BOOT
FIRE EXTINGUISHER

EXTERIOR

FRONT WHEELS : COMPOMOTIVE MO, 7 I/2in x 17in ET 37
GOODYEAR EAGLE F1’s 215/40

REAR WHEELS : COMPOMOTIVE MO, 8in x 17in ET 35
GOODYEAR EAGLE F1’s 215/40

ALL PAINTED IN ANTHRACITE WITH DIAMOND CUT & POLISHED RIM

GENUINE RS500 FRONT SPLITTER
GENUINE RS500 FOGLIGHT GRILLES, WITH AIR DUCTING TO AIR FILTER
SPEC-R REAR BUMPER/EXHAUST HEAT SHIELD

[2om]

Ну и не без фото.





Копирайт Ian3dr, PassionFord.

Так же комментарии Яна на английском.

As some of you know, I won the Gold Cup last year for the cleanest Modified Cosworth 2004 3 days after winning the cup in September, the car was stripped to a shell once again, and the entire floor pan, wheel arches and engine bay were bare metalled. Ant (3drbadboy) managed to borrow a body shop off of a friend for the weekend, so we managed to paint it all in there in one hit. This was November 2004. A huge pile of new parts were waiting to go on the car once painted, and also most of the alloy has been chromed as much to popular belief, I hate polishing! lol!

The car was actually totally finished at the end of Febuary this year, so 5 months from start to complete. A HUGE thanks to Ant for all his hard work helping me with the car

A few of the pics were taken on a 4 poster. This was when it as MOT'd last week. The MOT mans face was a picture as it went up in the air and he saw what I had done to the underneath! Still charged me £40 though!

Hope you like the pics The car will be at every regional show this year

[Berch]

Мало че понял, но впячетляет.

[Ustas]

2om
Нда..
Не трави душу

[СташЫк]

Везёт же людям

[SLEX]

А не пишет во сколько $ обошлось это чудо?

[2om]

http://www.spec-r.co.uk/
http://www.grahamgoode.com

и.т.п.

Можно в онлайне посчитать.

[SLEX]

Не,посчитаю в Off-е,по Burton-овскому каталогу за этот год,потом пропишу...

[SLEX]

ENGINE

200 COSWORTH BLOCK - 750.00
STANDARD STEEL CRANK, STANDARD STEEL CON RODS - 1350.00 + 230.00
GENUINE COSWORTH PISTONS - 450.00
LOW COMPRESSION (7.6:1)
HIGH PRESSURE OIL PUMP - 164.99
BIG WINGED SUMP (1 litre extra) ~ 400
WRC METAL 4 LAYER HEAD GASKET ~ 140
LONG STUDDED
4X4 POLISHED & PORTED HEAD ~ 600
HARVEY GIBBS CAMS ~ 670 (набор)
KENT ADJUSTABLE VERNIERS
PORTED INLET MANIFOLD AND PLENUM
INLET MANIFOLD ‘O’ RINGED
4X4 EXHAUST MANIFOLD
GT28 ROLLER BEARING TURBO WITH MODIFIED T34 FRONT HOUSING – 849.95
GARRETT –31 ACTUATOR – 79.50
GROUP A CAM BELT –35.00
GROUP A COIL – 49.95
GENUINE RS500 INTERCOOLER WITH MODIFIED T34 FITTINGS – 399.50
PACE RS500 FAST ROAD RADIATOR (50mm core) – 376.00
PRO-ALLOY SLIMLINE UPRATED COOLING FANS ~ 150.00
PACE TURBO COOLER – 169.95
BAILEY MOTORSPORT TURBO OIL FEED & PRE FILTER – 38.75
SPEC-R GROUP A BREATHER/SEPARATOR SYSTEM – 39.95
SPEC-R CAMBELT COVER
SPEC-R SWIRL POT
SPEC-R WATER COOLED POWER STEERING TANK
SPEC-R HEADER TANK (with sight glass)
SPEC-R WASHER BOTTLE
STANT 21-25psi RADIATOR CAP WITH LEVER RELEASE
SAMCO BOOST & WATER HOSES
BRAIDED FUEL HOSE -6 WITH EARLS FITTINGS AND CLAMPS
(from filter to fuel rail, and regultor to tank)
MIKALOR STAINLESS STEEL HOSE CLAMPS THROUGHOUT
2 AIR SCOOPES ABOVE INTERCOOLER WITH DUCTING TO AIR FILTER
MONGOOSE 3in STAINLESS STEEL EXHAUST (with Powerflex hangers)
K&N GROUP A CONE FILTER
WEBBER MARELLI LEVEL 8 ECU WITH PECTEL BABY BOARD
PECTEL 12 POSITION BOOST CONTROL (in car)
4 X 403 GREY INJECTORS (503cc) – 99.95 x 4
WRC AIR INJECTORS WITH –4 BRAIDED HOSE AND EARLS FITTINGS
WATER INJECTION
044 FUEL PUMP – 211.50
3 BAR MAP SENSOR
MOTORCRAFT AGP 701 SPARK PLUGS
FORD MOTORSPORT IGNITION LEADS
MILLERS 10w60 FULLY SYNTHETIC OIL
9 OIL COOLER FOR POWER STEERING ~ 50.00


TRANSMISSION

STANDARD BORG WARNER T5 WITH QUICKSHIFT (quickshift – 150.00)
CASTROL AUTOMATIC TRANSMISSION FLUID (as standard)
LIGHTENED & BALANCED FLY WHEEL – 157.50
ALCON 6 PADDLE, STANDARD FORD COVER
RECONDITIONED PROPSHAFT WITH UPRATED UJ’S
QUAIFE ATB 7 ½ INCH DIFF, 3.64:1 FINAL DRIVE (standard)
CASTROL EP80W-90 OIL


POWER

405 bhp @ 6030 rpm
397 lbft TORQUE @ 4020 rpm
REV LIMITER : 7100 rpm
PEAKS @ 32 psi, HOLDS 28psi
BUILT & TUNED BY HARVEY GIBBS
SCS, PETERBOROUGH. 01733 576614
MAPPED BY AHMED BAYJOO ON DYNO & IN CAR


BRAKES

FRONT: AP RACING CP5555 6 POT CALIPERS
330mm x 28mm DISCS & BELLS
FERRADO DS2500 PADS

REAR: 4x4 CALIPERS
300mm x 22mm DISCS & BELLS
FERRADO PADS
GOODRIDGE BRAIDED HOSES ALL ROUND
CASTROL SRF DOT 4 BRAKE FLUID


SUSPENSION

FRONT: GAZ COILOVERS
10 INCH SPRINGS, 325 LB
POLY BUSHED ANTI ROLL BAR AND TRACK CONTROL ARMS (inner
& outer)
SPEC-R TWIN BAR STRUT BRACE (chromed)


REAR: GAZ COILOVERS
12 INCH SPRINGS, 225LB
GROUP N REAR BEAM BUSHES (donuts)
STANDARD FORD TRAILING ARM BUSHES
POLY BUSHED REAR ANTI ROLL BAR
REAR SHIM KIT
SPEC-R REAR STRUT BRACE

INTERIOR

STANDARD RECARO INTERIOR
RS MOTORSPORT 3 SPOKE STEERING WHEEL
WILLINS 4 POINT HARNESSES
ELLIOT 8000 RPM REV COUNTER
DEFI OIL PRESSURE & TEMPERATURE AND EXHAUST GAS TEMPERATURE
DEFI CONTROLLER (with record and playback)
APEXI 2.5 BAR BOOST GUAGE (with record and playback)
S.E.C.S MONITER
PECTAL 12 POSITION BOOST CONTROL
SPEC-R WATER INJECTION TANK IN BOOT
FIRE EXTINGUISHER

EXTERIOR

FRONT WHEELS : COMPOMOTIVE MO, 7 I/2in x 17in ET 37
GOODYEAR EAGLE F1’s 215/40

REAR WHEELS : COMPOMOTIVE MO, 8in x 17in ET 35
GOODYEAR EAGLE F1’s 215/40

ALL PAINTED IN ANTHRACITE WITH DIAMOND CUT & POLISHED RIM

GENUINE RS500 FRONT SPLITTER
GENUINE RS500 FOGLIGHT GRILLES, WITH AIR DUCTING TO AIR FILTER
SPEC-R REAR BUMPER/EXHAUST HEAT SHIELD

Итого 7.912,34
это по каталогу Burton Power за 2005 год.Цены на то, что в принципе не родное и по- идее должно было заменяться.(Кстати, цены в англицких фунтах 10214146 SIERRA COSWORTH 16V 4X4 LIM/4 1994 220/162 01/90-03/93 Цена - 71321 вот только не знаю,марок или уже евров(обзор за 2002 год)